Motorola R2410 Random Shutdown?
Moderator: Queue Moderator
-
- New User
- Posts: 5
- Joined: Tue Feb 23, 2010 6:24 am
- What radios do you own?: Motorola System Saber III
Motorola R2410 Random Shutdown?
Anybody with a Motorola R2200/2400 Series service monitor had any problems with the unit shutting down and require a power off/on to restart. I have the complete service manual and there is a 75 C overtemp N/C relay that could cause the issue but never been able to duplicate. Other issues like line voltage too high will force a shutdown, but have ruled that one out with a steady 120/121 VAC. The Unit is about 20 years old and a R2410. It is in perfect working orderand mint condition with the exception of the random shutdown! Help?
Re: Motorola R2410 Random Shutdown?
Mine has the same problem. Never worried about it. It always starts up again.
"The world runs on radio."
Re: Motorola R2410 Random Shutdown?
I had a R2600 series that had the same problem, it turned out to be the power FETs (TO3) in the power supply module. It had loose screws and were shorting out the unit sending it into over current protection.
-
- New User
- Posts: 5
- Joined: Tue Feb 23, 2010 6:24 am
- What radios do you own?: Motorola System Saber III
Re: Motorola R2410 Random Shutdown?
I took another look at the power supply module this last weekend and everything is tight! All the soldered in components look good as well! Also I realized after looking at the original paperwork that I have had the unit since 1988! That's 30 years! Will just have to keep power cycling when needed.
Thanks for the input!
Thanks for the input!
Re: Motorola R2410 Random Shutdown?
Electrolytic capacitors that are over 20 years old are always suspect.
Tantalum capacitors are known for shorting out - even intermittently. Usually a piece of equipment will have dozens if not hundreds of those. For some reason 10uF tantalums are very common and seem to fail the most. Hopefully one will short out for good one day; then you can find it and replace it.
Bob M.
Tantalum capacitors are known for shorting out - even intermittently. Usually a piece of equipment will have dozens if not hundreds of those. For some reason 10uF tantalums are very common and seem to fail the most. Hopefully one will short out for good one day; then you can find it and replace it.
Bob M.
-
- New User
- Posts: 5
- Joined: Tue Feb 23, 2010 6:24 am
- What radios do you own?: Motorola System Saber III
Re: Motorola R2410 Random Shutdown?
Thanks for the tips.....none of the radial caps are swollen that usually indicates a issue. It is just going to have to quit for me to continue looking. Intermittent issues are the worst in the electronics business to isolate!
Bill K
Bill K